烟气增湿对粉尘特性及电除尘性能的影响规律

详细信息    查看全文 | 推荐本文 |

英文篇名：Law of influence of flue gas humidification on dust characteristics and electric dust removal performance 作者：黄宇 英文作者：Huang Yu;ChongQing Water Resources And Electeic Engineering College; 关键词：电除尘器 ; 提效技术 ; PM_(2.5) ; 团聚 英文关键词：ESP;;efficiency-raising technology;;PM_(2.5);;agglomeration 中文刊名：烧结球团 英文刊名：Sintering and Pelletizing 机构：重庆水利电力职业技术学院; 出版日期：2019-08-15 出版单位：烧结球团 年：2019 期：04 基金：重庆市教委科学技术研究项目(KJ1735450) 语种：中文; 页：66-71 页数：6 CN：43-1133/TF ISSN：1000-8764 分类号：X701.2

摘要

通过搭建电除尘提效试验系统,对不喷雾、喷水、喷碳酸钠溶液后的粉尘特性、电除尘器性能及SO_x脱除性能进行研究。结果表明:喷水、喷碳酸钠溶液后,飞灰工况比电阻均有大幅降低,分别从7.02×10~(12)Ω·cm降为6.15×10~(11)、1.24×10~(11)Ω·cm,且细颗粒物团聚现象明显,PM_(2.5)质量浓度明显降低;电除尘器总尘脱除效率分别从99.77%提高到99.86%和99.91%,PM_(2.5)的脱除效率分别从96.68%提高到98.07%和98.42%;在脱除烟气中SO_x性能方面,喷水对脱SO_2作用并不明显,但可配合电除尘器实现35.0%的SO_3脱除效率,喷碳酸钠溶液后,电除尘器对SO_2、SO_3的脱除效率分别为41.3%、80.6%。本研究可为燃煤烟气、烧结烟气、窑路烟气等电除尘器的提效改造提供一种新的技术思路。
        By setting up the electric dust removal and efficiency improvement test system,the dust characteristics,the performance of the electric dust collector and the SO_x removal performance are studied after no spraying,spraying of water and spraying of sodium carbonate solution.The results show that,after spraying of water and spraying of sodium carbonate solution,the specific resistance of fly ash in working condition is significantly lower than that of non-spraying of anything,reducing from normal(non-spraying)7.02×10~(12) Ω·cm to 6.15×10~(11) Ω·cm and 1.24×10~(11) Ω·cm respectively;moreover,the aggregation of fine particles is obvious,and the mass concentration of PM_(2.5) is significantly reduced.In terms of the ESP performance,the removal efficiency of total dust is increased from 99.77% to 99.86% and 99.91% respectively.The removal efficiency of PM_(2.5) is increased from 96.68% to 98.07% and 98.42% respectively.In terms of SO_x removal of flue gas,water spraying has no obvious effect on SO_2 removal,but 35.0% removal efficiency of SO_3 can be achieved in cooperation with the ESP.After spraying of sodium carbonate solution,the removal efficiency of SO_2 and SO_3 by ESP is 41.3% and 80.6% respectively.This study can provide a new technical idea for improving the efficiency of ESP of coal-fired flue gas,sintering flue gas and kiln flue gas.

引文

[1] Zhang X.On energy consumption and atmospheric pollutants of China's iron and steel industry[J].Iron & Steel,2000,35(1):63-68;72.
    [2] 范晓慧,甘敏,季志云,等.烧结烟气超细颗粒物排放规律及其物化特性[J].烧结球团,2016(3):42-45.
    [3] 李海英,王锦,郑雅欣.烧结过程细微颗粒物排放特征与控制方法[J].环境工程,2018,36(8):102-106.
    [4] 郄俊懋,张春霞,王海风,等.烧结烟气典型污染物排放形势及减排技术分析[J].烧结球团,2016(6):59-64.
    [5] 刘宪.烧结机头电除尘灰制取一氧化铅试验研究[J].烧结球团,2012,37(4):71-74.
    [6] 中国环境保护产业协会.电除尘器选型设计指导书[M].北京:中国电力出版社,2013.
    [7] 李宁,袁伟锋,刘含笑,等.基于电湍耦合凝并机制的PM2.5捕集增效装置的开发及应用[J].中国电力,2018,51(6):17-25.
    [8] 秦占峰,朱宝宇,郭沂权,等.300 MW燃煤电站细颗粒物化学团聚系统运行及经济性分析[J].洁净煤技术,2019,25(1):131-135.
    [9] 何剑,刘道清,周茂军,等.电凝并增效在烧结机头烟尘净化中的应用[C]//第十六届中国电除尘学术会议论文集.武汉:中国环保产业协会电除尘委员会,2015.
    [10] 王臻.烧结烟气微细颗粒物排放特性及其与高分子团聚剂溶液界面化学关系[D].合肥:安徽工业大学,2018.
    [11] Bickelhaupt R E,Sparks L E.Predicting fly ash resistivity-an evaluation[J].Environment International,1981,6(1):211-218.