SDS促进复合酶水解法提取剩余污泥蛋白质条件的响应面优化分析

详细信息    查看全文 | 推荐本文 |

英文篇名：Optimization of Extraction Conditions of Protein Extracted from Excess Sludge by both SDS and Complex Enzyme by Response Surface Methodology 作者：夏雄 ; 邓妍 ; 刘威 ; 陆天阳 ; 许霞 ; 王怡人 ; 罗俊杰 英文作者：XIA Xiong;DENG Yan;LIU Wei;LU Tianyang;XU Xia;WANG Yiren;LUO Junjie;School of Environment and Safety Engineering,Changzhou University;Huaide College,Changzhou University;Supervision Center,Handan Environmental Protection Bureau; 关键词：剩余污泥 ; 蛋白质 ; 复合酶 ; 水解法 ; 十二烷基硫酸钠 ; 响应面优化 英文关键词：excess sludge;;protein;;complex enzyme;;hydrolysis method;;sodium dodecyl sulfate(SDS);;response surface optimization 中文刊名：KTAQ 英文刊名：Safety and Environmental Engineering 机构：常州大学环境与安全工程学院;常州大学怀德学院;邯郸市环境保护局督查中心; 出版日期：2018-12-13 08:59 出版单位：安全与环境工程 年：2018 期：v.25;No.120 基金：国家自然科学基金项目(21607017) 语种：中文; 页：KTAQ201806008 页数：7 CN：06 ISSN：42-1638/X 分类号：52-58

摘要

以江苏省常州市某市政污水处理厂的污泥为原料,将十二烷基硫酸钠(SDS)作为添加剂,研究其对复合酶(碱性蛋白酶∶木瓜蛋白酶=4∶1)水解法提取剩余污泥蛋白质的促进作用,并根据前期试验结果,在确定液固比为5∶1和复合酶加酶量为5.23%的条件下,以剩余污泥蛋白质的提取率为指标,通过对SDS投加量、反应温度、初始pH值和反应时间因素进行单因素试验和响应面优化试验,确定SDS促进复合酶水解法提取剩余污泥蛋白质的最佳提取条件和各因素对SDS促进复合酶水解法提取剩余污泥蛋白质提取率的影响显著性大小。结果表明:最佳提取条件为液固比5∶1、复合酶加酶量5.23%、初始pH值7.4、反应温度56.9℃、反应时间2.6h、SDS投加量8.16%;在最佳提取条件下剩余污泥蛋白质提取率的最大值可达69.12%,比仅使用复合酶的提取率(60.83%)提高了8.29%;各因素对SDS促进复合酶水解法提取剩余污泥蛋白质的影响显著性由强至弱表现为反应温度>初始pH值>SDS添加量>反应时间。
        This paper uses the excess sludge which comes from a municipal wastewater treatment plant in Changzhou,Jiangsu province as raw material,and uses SDS as an additive to study its promoting effect on the extraction of excess sludge protein from complex enzyme(alkaline protease∶papain=4∶1).According to the results of previous experiments,the liquid solid ratio is 5∶1 and complex enzyme dosage is 5.23%.Taking the protein extraction rate of the excess sludge as an index,the paper carries out single factor test and response surface optimization test on SDS dosage,reaction temperature,initial pH and reaction time.The optimum extraction conditions are as follows:liquid solid ratio 5∶1,complex enzyme dosage 5.23%,initial pH 7.4,reaction temperature 56.9℃,hydrolysis time 2.6 h,SDS dosage 8.16%.The maximum protein extraction rate of the excess sludge is 69.12%,which is8.29% higher than that of the complex enzyme only.The rank of the influence of all factors from strong to weak is:reaction temperature>initial pH>SDS dosage>reaction time.

引文

[1]苏瑞景.剩余污泥酶法水解制备蛋白质、氨基酸及其机理研究[D].上海:东华大学,2013.
    [2]陆钧皓.复合酶水解法提取剩余污泥中蛋白质的研究[D].上海:东华大学,2015.
    [3]Morea T T.Extracellular polymeric substances of bacteria and their potential environmental applications[J].Environmental Management,2014,144:1-25.
    [4]Yu G H,He P J,Shao L M,et al.Enzyme extraction by ultrasound from sludge flocs[J].Journal of Environmental Sciences,2009,21(2):204-210.
    [5]Zhang W F,Sui R J,Li D X,et al.Extraction of amino acids from excess activated sudge by enzymatic hydrolysis[J].Journal of Donghua University(English Edition),2013,30(1):44-48.
    [6]于静.表面活性剂促进剩余污泥酶水解的研究[D].长沙:湖南大学,2011.
    [7]马欣.生物酶法提取剩余污泥蛋白质的研究[D].天津:天津理工大学,2016.
    [8]黄翔峰,穆天帅,申昌明,等.表面活性剂在剩余污泥处理中的作用机制研究进展[J].环境工程学报,2016,10(12):78-85.
    [9]朱峥嵘,石崇,朱颖一,等.响应面法优化纳米Fe3O4/CaO2处理含PAEs废水的研究[J].安全与环境工程,2018,25(3):1-7.
    [10]成岳,唐伟博,肖治国,等.一步法制备纳米Fe@SiO2及其处理含Pb(Ⅱ)废水性能的研究[J].安全与环境工程,2018,25(2):88-94.